How to fix miter saw blade guard and is the blade too loose?
My miter saw was in storage for the last few months and when I took it out to give it a test run, I noticed that when you lower the blade, the guard does not lift up. The guard can be moved with my hand, so its not stuck. How can I fix this? Any ideas?
Also, the blade itself seems to be a little loose, like swaying from side to side, but only a very tiny tiny bit. It doesn't seem to bother cutting any wood, but I was afraid it might loose too much. This I can lookup in my manual, the blade guard is what I am trouble with the most.
The guard issue is difficult to address. There are several ways that these can be configured, without a model or even a manufacturer, it is hard to guess. There is some kind of linkage between the guard and the pivot point of the saw, part of this is loose. Again, hard to know where to tell you to look more specifically.
The loose blade is a different story. A few possibilities there.
Could be the wrong blade. There are different sizes and shapes of arbors (and holes in the center of the blade). Putting the wrong blade on the saw will cause a problem. I doubt that this is your problem.
Could simply be that the nut that holds the blade on is a bit loose. If this is the case, it is hazardous to operate the saw. You need to check this before you operate the saw again. Sometimes the bolt or nut holding the blade will become a bit rusted and feel tight before it is, so remove it, clean if needed and reinstall. This should not come loose from storage, if it is loose it probably was loose when you put it in storage.
Last possibility is a bearing problem. As the bearings in the saw wear, they will allow the spindle to wobble a bit. If you can wiggle the spindle a bit with no blade on the saw, this is your problem. It should take a bit of use to wear the bearings, but they can go early if you try to cut material that is too heavy for the saw or try to cut too fast. Cheaper saws will tend to wear faster than a more expensive saw. This will cause your cuts to be a bit less accurate, but you can use the saw with a bit of wear. Once it starts to wobble it will get worse quickly, so plan to repair or replace soon.
![]() |
![]() 7 1 4 Carbide Tip Circular Saw Blade $14.50 Time Remaining: 1d 13h 24m Buy It Now for only: $14.50 |
![]() NEW Polar Flying Dutchman Scroll saw Blades Mix and Match 2 013579 $4.00 Time Remaining: 2d 11h 41m Buy It Now for only: $4.00 |
![]() 25 Assorted Craftsman Pin End Scroll Saw Blades $10.50 (3 Bids) Time Remaining: 2d 18h 45m |
![]() 70 Wood Band Olson Band Saw Blades $15.95 Time Remaining: 5d 14h 21m Buy It Now for only: $18.95 |
![]() PROXXON 28017 20 CARBIDE TIPPED MINI SAW BLADE KS 115 $27.80 Time Remaining: 5d 19h 43m Buy It Now for only: $27.80 |
![]() 12 COPING SAW BLADES Wood Blade Craft Free Shipping $7.99 Time Remaining: 6d 7h 18m Buy It Now for only: $8.99 |
![]() 80 Olson Band Saw Blades $14.95 Time Remaining: 6d 11h 27m Buy It Now for only: $16.95 |
![]() 82 Olson Band Saw Blades $15.95 Time Remaining: 6d 11h 30m Buy It Now for only: $17.95 |
![]() 93 1 2 Olson Band Saw Blades $16.95 Time Remaining: 6d 11h 33m Buy It Now for only: $18.95 |
![]() 93 1 2 Lenox Pro Master I Saw Blades $3.25 Time Remaining: 6d 11h 43m Buy It Now for only: $3.25 |
![]() 93 1 2 Lenox Pro Master I Saw Blades $3.25 Time Remaining: 6d 11h 45m Buy It Now for only: $3.25 |
![]() Circular Saw Blade for Cutting Wood 3 $7.50 Time Remaining: 6d 12h 27m Buy It Now for only: $7.50 |
![]() Olsen Scroll Saw Blades $16.00 Time Remaining: 6d 14h 38m Buy It Now for only: $16.00 |
![]() Olsen Scroll Saw Blades $17.00 Time Remaining: 6d 14h 40m Buy It Now for only: $17.00 |
![]() Olsen Scroll Saw Blades $15.00 Time Remaining: 6d 14h 41m Buy It Now for only: $15.00 |
![]() Olsen Scroll Saw Blades $12.00 Time Remaining: 6d 14h 44m Buy It Now for only: $12.00 |
![]() Olsen Scroll Saw Blades $12.50 Time Remaining: 6d 14h 45m Buy It Now for only: $12.50 |
![]() Olsen Scroll Saw Blades $12.25 Time Remaining: 6d 14h 47m Buy It Now for only: $12.25 |
![]() Olsen Scroll Saw Blades $24.00 Time Remaining: 6d 14h 57m Buy It Now for only: $24.00 |
![]() Olsen Scroll Saw Blades $24.00 Time Remaining: 6d 14h 58m Buy It Now for only: $24.00 |
![]() Olsen Scroll Saw Blades $24.00 Time Remaining: 6d 14h 59m Buy It Now for only: $24.00 |
![]() Olsen Scroll Saw Blades $30.00 Time Remaining: 6d 15h 1m Buy It Now for only: $30.00 |
![]() Trojan Jig Saw Blades 5 15 Teeth 020 thick 110 wide $4.50 Time Remaining: 8d 21h 25m Buy It Now for only: $4.50 |
![]() Delta QUICKSET II BLADE CHUCK for 161820 Scroll Saws $12.00 Time Remaining: 9d 11h 45m Buy It Now for only: $12.00 |
![]() Saw Blade Germany 1 Diameter 1 16 hole FREEshipUSA $4.99 Time Remaining: 11d 20h 5m Buy It Now for only: $4.99 |
![]() 6 Dozen Flying Dutchman Scroll saw Blades scroll reverse tooth 13579 or 12 $22.00 Time Remaining: 12d 19h 34m Buy It Now for only: $22.00 |
![]() Flying Dutchman Scroll saw Blades scroll reverse by The Dozen 13579or12 $4.00 Time Remaining: 14d 6h 54m Buy It Now for only: $4.00 |
![]() Flying Dutchman Spiral Scroll saw Blades by the Dozen 2 0 1 3 5 7 $4.00 Time Remaining: 15d 18h 21m Buy It Now for only: $4.00 |
![]() Micro Fine Tooth Rotary Saw Blade $3.99 Time Remaining: 16d 16h 3m Buy It Now for only: $3.99 |
![]() Small Tooth Rotary Saw Blade $3.99 Time Remaining: 16d 16h 7m Buy It Now for only: $3.99 |
![]() PROXXON 28014 CROSS CUT SUPER CUT SAW BLADE KS115 $14.20 Time Remaining: 18d 7h 37m Buy It Now for only: $14.20 |
![]() Ultra Reverse Tooth Flying Dutchman Scroll saw Blades Mix and Match 13579 $4.00 Time Remaining: 21d 12h 50m Buy It Now for only: $4.00 |
![]() 6 Dozen Ultra Reverse Tooth Flying Dutchman Scroll saw Blades 13579 $22.00 Time Remaining: 21d 13h 1m Buy It Now for only: $22.00 |
![]() Learn TWIN BLADE CUTTING on the table saw Instructions $3.50 Time Remaining: 23d 10h 37m Buy It Now for only: $3.50 |
![]() All Pro Professional Series Band Saw Blade 105 $26.95 Time Remaining: 23d 14h 17m Buy It Now for only: $26.95 |
![]() 4 Blades Mini Table Saw Diamond Blade 24 Tooth Blade $69.99 Time Remaining: 26d 9h 43m Buy It Now for only: $69.99 |
![]() Flying Dutchman Scroll saw Blades scroll reverse Mix and Match 13579or12 $4.00 Time Remaining: 26d 12h 22m Buy It Now for only: $4.00 |
![]() X ACTO X234 SHALLOW CUT FINE SAW BLADE 40 TPI $4.25 Time Remaining: 29d 11h 7m Buy It Now for only: $4.25 |
![]() X ACTO X235 MEDIUM DEPTH CUT SAW BLADE 40 TPI $4.25 Time Remaining: 29d 12h 56m Buy It Now for only: $4.25 |







































